Product ID:REPLENISHER, BLACK, RP-58B: 22534-0017
MSDS Date:06/16/1995
FSC:6750
NIIN:00N070496
MSDS Number: CBLXZ

CALCOMP

2411 WEST LA PALMA AVE
ANAHEIM, CA 92901
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 714-821-2556

Cage: IO122

CALIFORNIA COMPUTER PRODUCTS SUB OF SANDERS ASSOC

3250 ANAHEIM, CA 92803 US

Telephone: 714-821-2290

Cage: 14668

MINERAL SPIRITS; (MIXED C*8 - C*12 ALKANE ISOMERS, N.O.S)

CAS: 64475-85-0

RTECS: PY8240000

Fraction By Weight: >90.0%

OSHA PEL N/K

ACGIH TLV: N/K

ACRYLIC POLYMER/RESIN; (ACRYLIC COPOLYMER/RESIN)

CAS: 28430-58-2

Fraction By Weight: <7.0%

OSHA PEL N/K

ACGIH TLV: N/K

CARBON BLACK; (PIGMENT)

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: <3.0%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3; 9495

LD50 LC50 Mixture:LD50 (ORAL, RAT): 5 G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES:IRRITANT TO EYES-MAY CAUSE
CONJUNCTIVITIS. SKIN:PRLNG CONTACT CAUSES DEFATTING, DRYING,
CRACKING, DERMATITIS. INHAL:NOT NORMALLY AN INHAL HAZARD.
INGEST:NAUSEA & POSSIBLE GASTRO-INTESTINAL IRRIT. SIGNS & SYMPS OF
OVEREXP:OVEREXP BY INHAL MAY CAUSE HEADACHE, NAUSEA, & RESPIRATORY
IRRITATION. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: POTENTIAL HEALTH EFFECTS: PERSONNEL
WITH PRE-EXISTING HEALTH CONDITIONS OF DERMATITIS AND RESPIRATORY
AILMENTS MAY NOTICE PHYSICAL REACTIONS WHEN EXPOSED TO SMALL
AMOUNTS OF PRODUCT OR VAPOR . CONSULT THEIR TREATING PHYSICIAN FOR
PROPER ACTION AFTER EXPOSURE. TARGER ORGANS: EYES, SKIN,
RESPIRATORY SYSTEM.
Medical Cond Aggravated by Exposure:DERMATITIS. REPEATED INHALATION
EXPOSURE TO RAT OF A SIMILAR HYDROCARBON AT CONCENTRATIONS GREATER
THAN OR EQUAL TO 300 PPM IN AIR CAUSED LOW GRADE (MILD) ANEMIA AND
KIDNEY EFFECTS.

First Aid:EYES:FLUSH W/LRG AMTS OF H*2O FOR AT LEAST 15 MIN, OR UNTIL
IRRIT SUBSIDES, INCL UNDER EYELIDS. IF IRRIT PERSISTS. CNTCT MD.
SKIN:REMOVE CONTAMD CLTHG. WASH SKIN THORO W/SOAP & H*2O. DO NOT
REUSE CONT AMD CLTHG UNTIL SOLV HAVE BEEN REMOVED.INHAL:MOVE VICTIM
TO FRESH AIR. CALL MD IMMED. IF BRTHG IS IRREG/STOPPED, START
RESUSCITATION IF TRAINED. ADMIN OXYGEN IF AVAIL. INGEST:DO NOT
INDUCE VOMITING DU E TO ASPIRATION HAZARD. CALL A PHYSICIAN.

Flash Point Method:TCC
Flash Point:>103F,>39C
Lower Limits:0.8%
Upper Limits:7.0%
Extinguishing Media:FOAM, DRY CHEMICAL, CO*2 (CARBON DIOXIDE), WATER
FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID WATER, IT TENDS TO SPREAD HYDROCARBON FIRES.
Unusual Fire/Explosion Hazard:NONE. GENERAL HAZARD: COMBUSTIBLE LIQUID,
CAN FORM COMBUSTIBLE MIXTURES AT OR ABOVE THE FLASHPOINT.

Spill Release Procedures:REMOVE IGNITION SOURCES. COLLECT ON INERT
ABSORBENT MATERIAL. PLACE IN WASTE CONTAINER APPROVED FOR
COMBUSTIBLE WASTE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN CLOSED, COOL, WELL VENTILATED
AREA, AWAY FROM HEAT AND FLAME. READ AND FOLLOW LABEL PRECAUTIONS.
DO NOT REUSE CONTAINER.
Other Precautions:KEEP CNTNRS CLSD WHEN NOT IN USE. DO NOT SMOKE WHEN
USING PROD. MINIMIZE BRTHG VAP/MIST. USE W/ADEQ VENT. AVOID
PRLNG/RPTD SKIN CNTCT. EMER OVERVIEW: A BLACK LIQ WHICH IS COMBUST.
MFR & BOTTLED FOR US E IN CALCOMP PLOTTERS. EXPOS TO PLOTTERS.
EXPOSE TO VAPS & FIRE HAZ SHOULD BE MIN WHEN STORED PROPER LY &
(OTHER INFO)

Respiratory Protection:NOT REQUIRED WHEN USED AS INTENDED. IN
CONCENTRATIONS EXCEEDING THE RECOMMENDED SAFE EXPOSURE LIMIT, SUCH
AS DURING A MAJOR SPILL, USE NIOSH/MSHA APPROVED CHEMICAL CARTRIDGE
RESPIRATOR EFFECTIVE FOR O RGANIC VAPORS.
Ventilation:LOC EXHST; TO MAINTAIN BELOW TLV. NORM OFFICE VENT
CONFORMING TO AMERICAN SOCIETY OF HEATING, REFRIGERATING, & AIR
CONDITIONING ENGINEERS (ASHRAE) (SUP DAT)
Protective Gloves:LATEX GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
WEAR CHEM RESIST APRON WHEN CLEANING MACHINES AS PROD MAY STAIN
CLTHG.
Work Hygienic Practices:WHENEVER HANDLING CHEMICALS, ALWAYS USE GOOD
PERSONAL HYGIENE PRACTICES, SUCH AS WASHING YOUR HANDS AFTER USING
PRODS.
Supplemental Safety and Health
VENT: 1980 STD IS ADEQ UNDER NORM CNDTNS OF USE. UNDER SOME CNDTNS OF
USE/COMBINATION OF EQUIP, OFFICE VENT MAY NOT BE ADEQ. USERS SHOULD
ASSURE THAT VENT IS SUFFICIENT TO PVNT EXCEEDING EXPOSURE LIMI TS.
USERS SHOULD CONSULT A QUALIFIED VENT ENGINEER AND/OR INDUS
HYGIENIST IF A CONCERN REGARDING EXPOSURE ARISES.

Boiling Pt:B.P. Text:>320F,>160C
Vapor Pres:1 @ 20C (58F).
Vapor Density:5
Spec Gravity:0.76 (H*2O=1)
Evaporation Rate & Reference:0.25-0.45 (N-BU AC =1)
Solubility in Water:IMMISCIBLE
Appearance and Odor:BLACK LIQUID WITH SLIGHT PETROLEUM HYDROCARBON
ODOR.
Percent Volatiles by Volume:80-100

Stability Indicator/Materials to Avoid:YES
VERY STRONG OXIDANTS LIKE CHROMIC ACID OR LIQUID CHLORINE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:NONE.

Waste Disposal Methods:WASTE TONERS & REPLENISHERS ARE HAZ WASTES AS
DEFINED BY 40 CFR CHAPTER 1 (FLAMM). TREAT AS HAZ WASTE & DISPOSE
I/A/W/ALL APPLIC FED, STATE & LOCAL DISP REG. DO NOT POUR DOWN
COMMON DRAIN. CONTACT A L ICENSED HAZ WASTE DISP COMPANY/ENVIRON
CONTROL AGENCY FOR ASSISTANCE. EPA WASTE NUMBER: RCRA HAZARDO US
WASTE NO. - D001.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.